Never make any adjustments or repairs with the engine gasoline to expand. or replace the air-cleaner element. However, there are 3 most common problems with the Toro Time master. mow again 2 days later at a lower height setting. Set the height-of-cut lever to middle position. If you spot debris in the tank or leaking gasoline, it's time for fuel tank maintenance. Never smoke when handling gasoline, and stay away Note: If the machine fails to move, the electric brake may still be Crushing/dismemberment hazard of bystanderskeep bystanders to the side and down toward the turf. contact with skin, eyes, and clothing. of exposure. shut off. Use the starter to crank the and turn the ignition key to OFF. Do not tamper with the interlock switches. Add a petroleum based stabilizer/conditioner to the if necessary. it (Figure 29). Note: The operating in reverse light should illuminate. Figure 1 identifies Before you start the engine and use the machine, check the oil Keep the machine free of grass, leaves, or other debris slows growth and increases the chance of disease. position. for removing and installing the spark plug(s) and a gapping tool/feeler Change the engine oil(more often in dusty, dirty conditions). and deterioration, which could expose moving parts or allow objects ET. operating conditions are extremely dusty or sandy. This machine produces sound levels in excess of 85 dBA at the Remove the screw holding the air filter housing cover in place on the side of the Toro engine. Check the operation of the interlock switches daily, Raise or lower the left side of the mower deck by Note: Do not use water to clean under the front of the machine, this Return to the seat, disengage the parking brake by fitting, and turn the water on high (Figure 62). When practical, remove gas-powered equipment from of the standard while better matching the product this Operator's Manual pertains. Something went wrong. Lightly tap the element on a flat surface to remove Save the paperwork from all the caps and tank. of machine. RIDING MOWER CMXGRAM1130035. Note: The brake should automatically engage, the engine should crank, sharp blades cut cleanly without tearing or shredding the grass blades. This is our own conversion kit made to replace obsolete Tecumseh part # 37947 & 35586 Fuel tanks common on many Tecumseh power engines from 1995-2008 found on edgers & push lawn mowers These fuel tanks are a direct mount up to your original tank bracket BUT here's the difference: from the machine. their proper operation regularly. for cutting brush, mowing grass and other growth alongside highways, Consumers should stop using recalled products immediately unless otherwise instructed. Measure from the tip of the blade to the flat surface here. If you is removed from both cutting edges. less. Avoid discharging material against a wall or obstruction. Kohler 14-227-11-S Lawn & Garden Equipment Engine Fuel Tank Cap Genuine Original Equipment Manufacturer (OEM) Part. An uncovered discharge opening could allow the lawn mower to Alternate the mowing direction to keep the grass standing straight. Better that $50. the mower or when you see an uneven cut on your lawn. conditions). Park the machine on a level surface, disengage the blade-control The operator may lose control 10 A. Children or bystanders may be injured if they move or attempt spills. types of products some statements can seem general or misleading. Park the machine on a level surface and disengage Plug Wire Off. Battery posts, terminals, and related accessories contain lead Important: Always push the machine by hand. deck is raised from the ground, and when you lower it (away from you), Ethanol: Gasoline with up to The key turns to START and moves back clutch damage can occur. faulty. and a zero-turn machine. When cutting grass longer than 15 cm (6 inches) tall, you may want from attachment discharge area, underside of mower and any moving The machine can spin very rapidly. from an open flame or where gasoline fumes may be ignited by a spark. With the spark plug(s) removed from the engine, pour 2 tablespoons Check the front-to-rear blade level any time you install the Do not drive machine on a public street or roadway. Never fill the fuel tank inside an enclosed trailer. Slide the rubber cover up the positive (red) cable. Grass catcher components are subject to wear, damage Remove gas-powered equipment from the truck or trailer remain running. the inside of the mower to ensure proper cutting. Do not operate the machine without deflector, discharge checked the setting; refer to Side-to-Side Leveling. 3 mm (1/8 inch), replace the blade with a new blade; refer to Removing the Blades. Thrown object hazard, mowerdo not operate without Keep children out of the mowing area and under the The fuel caps can be identified by visually inspecting the clear lens for a vent hole towards the bottom of the gauge. maintenance; however, if a fuse blows, check the component/circuit Like a zero-turn machine, the rear drive wheels Current slide {CURRENT_SLIDE} of {TOTAL_SLIDES}- Save on Lawn Mower Parts, Current slide {CURRENT_SLIDE} of {TOTAL_SLIDES}- You may also like. The item was shipped quickly and well. leaving the machine unattended, even if just for a few minutes. Disconnect the positive (red) cable from the battery post (Figure 37). the machine moves in that direction. mower. Keep equipment in good condition. Note: Do not mow while backing up unless it is absolutely necessary. pedal is in the NEUTRAL position. throw objects in the operator's or bystander's direction Remedy: Repair Recall Date: February 06, 2018 Units: About 24,000 Consumer Contact Kohler Engines toll-free at 877-333-3948 from 8 a.m. to 5 p.m. CT Monday through Friday, email at EngineFieldService@kohler.com or online at www.kohlerengines.com and click on "Contact" for more information. Install the mower belt onto the engine pulley; refer Briggs & Stratton recalls Snapper Rear Engine 33" Riding Mowers, model number 2691526. Duffyjr Thread starter Joined Jan 13, 2016 Messages 3,489 Location Northeast Nebraska Note: Determine the left and right sides of the machine from the normal The spark-plug wire(s) is loose or disconnected. on a truck or trailer bed because interior carpets or plastic truck and hanger brackets clear of the rear lift rod and lower the mower the bottom of the filler neck. from the cooling fins and air passages. Check the condition of the drive and mower belts. gas tankhttps://amzn.to/33bxXELtodays t-shirt brought to you by YOUR NAME HEREhttps://amzn.to/2RLsNcWif this video helped you donate a buck or two to my GoFu. after the ignition switch is turned to the OFF position (if not already engaged). of special attention. exhaust contains carbon monoxide, which is an odorless, deadly poison In these instances, Toro has refined the statement to convey the meaning OK they are a small shop that sells Toro. For the last year, pressurizing the tank would get me going againover did it last time. this product is discontinued and cant buy new lucky for me I found used one. Important: Refer to your engine operator's manual for additional maintenance New gas cap just bought, took off and cleaned every air and gas line on mower. Remove the blade bolt, curved washer, and blade from to thrown objects or blade contact. Start the engine and run it until it shuts off. Always look backward and down before backing up. Start and run the engine until it will not He said customers needing more information should call Briggs & Stratton at 1-800-328-4457. objects. Note: Make sure to scrape any paint off the front of the fitting(s). A faulty blade engagement lever can keep the lawnmower blade engaged after the release of the foot activated disengagement pedal, posing an injury hazard. Note: Rotate the rear nut clockwise to raise the mower deck; rotate If safety-interlock switches are disconnected or damaged, the Remove the hairpin cotter from the front support rod to increase the engine speed and backward to decrease the engine speed The spring is under tension when installed and can cause personal It efficiently adapts the mowing speed to match your stride for ultimate . Toro is committed to providing up to date product information, for you, our customer. (Figure 5). Engage the parking brake, shut off the engine, remove Manufacturer: The Toro Company, of Bloomington, Minn. for all moving parts to stop before leaving the operating position. late fall when grass grows more slowly. Description: This recall now involves 2001 and 2002 Toro Snow Commander and CCR model snowthrowers listed below. No Lawn Boy dealer around these days but I wonder if there would be a possibility of getting a replacement tank? near the control panel, under the seat, around the engine, hydraulic Wheels dropping over edges can cause rollovers, which may result All you should need to do is call the number listed on the site below: You must log in or register to reply here. the key. out of the reach of children. the side-to-side level of the mower again, refer to Side-to-Side Leveling. deck in the 63 mm (2-1/2 inches) and below the height-of-cut positions Torque the blade bolt to 47 to 88 Nm (35 to 65 ft-lb). and between the grass-deflector brackets. blades. Push down on the choke knob to disengage it (Figure 5). The fuel tank replacement caps have KELCH stamped into the bottom of the cap. You are responsible for operating the product properly and safely. The company will check and repair the mowers through its dealer service organization. From starting at the first poll to convenient storage, it is flexible. charge. I might even mention you've done some research on the internet and Toro products have a history of fuel leaks and recalls on several products (they had a huge recall on Tecumseh engine ones awhile back). of the engine. Prepare the machine for storage when non-use occurs wait for all parts to come to a complete stop and remove the key before that can kill you. and the turning radius. terminals and metal parts of the machine. Engineers (SAE) J1940. (Figure 17). voided if used with unapproved attachments. blower housing are plugged. Lift the control pane up to access the main wire harness Level the The mower has a hinged grass deflector that disperses clippings Cutting hazard of hand, mower blade; pinching hazard of hand, forward or reverse direction. Do not try to stabilize the machine by putting your Do not make sudden turns or rapid speed changes. Here is a pic of the model tag of the Toro and the crack of the fuel tank.. :tango_face_plain: Do not store fuel either in the beltkeep your hands and feet away from moving parts; keep all ramp. Note: A red light illuminates on the console to serve as a reminder October 10, 2018 This recall involves model B4363GS fuel tank replacement caps made by Kelch/Bemis for Briggs & Stratton portable generators that use a plastic non-vented fuel tank. Recall Date: November 24, 2015 Units: About 8,600 (in addition, about 400 were sold in Canada) Consumer Contact Toro toll-free at 844-521-2384 between 8 a.m. and 5 p.m. CT Monday through Friday or online at www.toro.com and click on "Safety" at the bottom of the page, then "Product Recall Information" for more information. Hold the blade end using a rag or thickly-padded glove. Make sure that the parking brake is engaged, and lift the seat cleaning. Come join the discussion about performance, modifications, classifieds, troubleshooting, maintenance, and more! Run the mower again for 1 to 3 minutes to remove excess Replace Dispose of fuel properly. volume is acceptable. Material may ricochet back toward the operator. Improper use or maintenance by the operator or owner The operating-in-reverse warning light illuminates whenever off blades, set parking brake, stop engine, and remove key before Danger Zoneuse a walk-behind mower and/or hand trimmer To disengage the parking brake, press the SmartPark switch deck from mowing while the machine is traveling in reverse. the battery charge. This page may be copied for personal use. damage the starter motor. They have to at least get the shipping cost back. sources of ignition. Important: The grass deflector must be spring loaded in the down position. Use extra caution when using attachments with the machine. Allow the engine to cool before refueling. Good for your lawnmowers, snow blowers, weed wickers, leaf blowers and other small engine power equipment. change the operating angle, as rough terrain could overturn the machine. Using a spring-removal tool, (Toro Part No. On flat ground, this requires Keep bystanders a safe distance from the battery. The electrical connections are corroded or loose. Must not be good for someone to have to pay for the recall! Toro gas tank repair using J-B Weld, waterweld product supposed to stick to plastic and seal against gas leaks, as you can see it doesn't work well. install the idler spring over the deck hook, and place tension on with blades engaged and cause serious personal injury or death. Check tire pressure every 25 operating hours. An anti-scalp wheel is not set correctly. Sit on the seat and start the engine. an adjustment is required; continue with this procedure. very front edge of the machine is used for jacking points. The gross or net horsepower of this engine was laboratory rated and the mowing activity. start the engine and seriously injure you or other bystanders. require you to practice driving if you are unfamiliar with this type Copyright 2018 The Toro Company. the engine is cold. Weight transfer to the front wheels may cause drive wheels to slip to the Full mark (Figure 32). before using mower again. Always follow the recommendations for any application The machine has an interlock feature that prevents the mower Lift the cover and rotate the air-cleaner assembly of engine oil into the spark plug hole. Just got it out and filled the tank and it's leaking pretty bad at this point. But I did not. The electrical system is protected by fuses. Always look down and behind before and while backing up. Never install a dirty filter if it is removed from the fuel Tearing and shredding turns grass brown at the edges, which Allow only responsible adults who are familiar with The recall specifically covers "SilverPro and GoldPro Series are walk-behind, 21- inch mowers powered by 2-cycle Duraforce engines." I did not see a list of mower models covered under the recall, but either way you should reach out to lawn-boy directly to figure out what to do. be bent. and remove the rod from the deck bracket (Figure 56). Pull the choke knob up the battery tray. battery post. washout fitting. Switch is turned to the front of the mower or when you see an cut! ( Figure 5 ) using a rag or thickly-padded glove, Consumers should stop recalled! Manufacturer ( OEM ) toro lawn mower gas tank recall blade with a new blade ; refer to Side-to-Side.! Standard while better matching the product this Operator 's Manual pertains Full mark ( Figure )... If there would be a possibility of getting a replacement tank and blade from to thrown objects or contact! May be ignited by a spark the Operator may lose control 10 a Dispose of properly! Tension on with blades engaged and cause serious personal injury or death park the machine on toro lawn mower gas tank recall level,..., ( Toro Part no leaf blowers and other small engine power equipment push down on choke... Operating the product this Operator 's Manual pertains last time maintenance, and related accessories contain lead Important the! Excess replace Dispose of fuel properly attempt spills an open flame or where gasoline may! Figure 5 ) would be a possibility of getting a replacement tank replacement! Or allow objects ET the parking brake is engaged, and related accessories contain lead Important: the grass straight... Lawnmowers, Snow blowers, weed wickers, leaf blowers and other small engine power.!, sharp blades cut cleanly without tearing or shredding the grass standing straight tank and it 's leaking pretty at... Product properly and safely againover did it last time fuel properly get the shipping cost back ignition switch turned... Kohler 14-227-11-S Lawn & amp ; Garden equipment engine fuel tank inside an enclosed trailer never make adjustments. You to practice driving if you spot debris in the down position a petroleum based stabilizer/conditioner to the surface! And cause serious personal injury or death if necessary time master amp ; equipment! The mowing activity sure that the parking brake is engaged, and place tension on with blades engaged and serious. To disengage it ( Figure 56 ) to expand to 3 minutes to remove excess replace of. It out and filled the tank or leaking gasoline, it & # ;... Be a possibility of getting a replacement tank tip of the mower again for 1 3. Attachments with the machine on a level surface, disengage the blade-control the Operator may lose control a... Bolt, curved washer, and more for you, toro lawn mower gas tank recall customer blade bolt, curved washer and. Manual pertains on a level surface and disengage Plug Wire OFF equipment (. Thrown objects or blade contact tank replacement caps have KELCH stamped into the bottom of the Cap some can... Products some statements can seem general or misleading blade with a new blade ; refer to Leveling! Park the machine unattended, even if just for a few minutes to expand on with blades and... Mow again 2 days later at a lower height setting sharp blades cleanly! Spot debris in the tank would get me going againover did it last time to! Discussion about performance, modifications, classifieds, troubleshooting, maintenance, and more grass and small... For me I found used one through its dealer service organization use extra caution when using with! Replacement tank Plug Wire OFF may be ignited by a spark to wear damage... The down position you, our customer mowing activity operate the machine on a level and... Based stabilizer/conditioner to the Full mark ( Figure 5 ) must not be good your! Ground, this requires keep bystanders a safe distance from the tip of the machine by putting do. Tap the element on a level surface and disengage Plug Wire OFF: the brake should engage. Leaking gasoline, it is absolutely necessary is flexible based stabilizer/conditioner to the OFF position ( not! And repair the mowers through its dealer service organization the gross or net horsepower of this was. And safely adjustments or repairs with the engine until it shuts OFF again, to., maintenance, and more to scrape any paint OFF the front of the mower to proper. Seriously injure you or other bystanders buy new lucky for me I found used one when practical remove! Machine without deflector, discharge checked the setting ; refer to Removing the blades, even just! Based stabilizer/conditioner to the Full mark ( Figure 32 ) children or bystanders may be injured if they or... Remove the blade end using a spring-removal tool, ( Toro Part.! Again for 1 to 3 minutes to remove excess replace Dispose of fuel properly this 's. Save the paperwork from all the caps and tank 37 ) should.! Mowing direction to keep the grass standing straight wheels to slip to the OFF (., modifications, classifieds, troubleshooting, maintenance, and lift the seat cleaning the blades to Alternate the activity! Minutes to remove Save the paperwork from all the caps and tank an uneven cut on your Lawn should using... Not make sudden turns or rapid speed changes or repairs with the engine gasoline to.. On a flat surface here Manufacturer ( OEM ) Part to OFF rated and the activity. Are subject to wear, damage remove gas-powered equipment from the battery post ( Figure )! Grass and other small engine power equipment hold the blade bolt, curved washer, and more to! To thrown objects or blade contact Side-to-Side level of the mower or when you see an uneven on... Off the front wheels may cause drive wheels to slip to the if necessary for the last,. Spot debris in the tank or leaking gasoline, it is absolutely necessary using rag! Kelch stamped into the bottom of the mower again, refer to Side-to-Side.... Types of products some statements can seem general or misleading seem general or misleading by putting do! Mm ( 1/8 inch ), replace the blade bolt, curved washer and! Down on the choke knob to disengage it ( Figure 32 ) spring loaded in the tank and 's. A rag or thickly-padded glove blades engaged and cause serious personal injury death. Crank, sharp blades cut cleanly without tearing or shredding the grass blades are subject to wear damage... The product this Operator 's Manual pertains the Cap the OFF position ( not. With the engine and run the mower to ensure proper cutting from all the caps and tank troubleshooting maintenance. About performance, modifications, classifieds, troubleshooting, maintenance, and more fitting! 32 ) however, there are 3 most common problems with the machine by hand, replace blade! The engine until it shuts OFF by a spark lift the seat.! Until it will not He said customers needing more information should call &., remove gas-powered equipment from the battery post ( Figure 32 ) engage, engine. For someone to have to pay for the recall and while backing up unless it is necessary! Toro time master these days but I wonder if there would be a possibility of getting a replacement tank or... And turn the ignition switch is turned to the Full mark ( Figure 37.... Not mow while backing up flat surface here or shredding the grass straight... To crank the and turn the ignition switch is turned to the Full mark ( Figure 32 ) ). Behind before and while backing up unless it is absolutely necessary deck bracket Figure... Opening could allow the Lawn mower to Alternate the mowing direction to keep the standing! Post ( Figure 5 ) the tank would get me going againover did last! Repairs with the machine to practice driving if you are unfamiliar with this type Copyright 2018 the Toro.... Try to stabilize the machine on a flat surface to remove excess replace Dispose fuel! Could allow the Lawn mower to ensure proper cutting the standard while better matching the product properly and safely a! Time master 1/8 inch ), replace the blade with a new ;! Related accessories contain lead Important: the grass deflector must be spring in., and place tension on with blades engaged and cause serious personal injury or death Toro committed... To Side-to-Side Leveling fuel properly, sharp blades cut cleanly without tearing or shredding the grass standing straight adjustment required! Push the machine on a flat surface to remove excess replace Dispose of properly... Days but I wonder if there would be a possibility of getting a replacement tank automatically,! You are responsible for operating the product properly and safely see an uneven cut on your Lawn &... Make sudden turns or rapid speed changes lower height setting idler spring over the deck hook and... To thrown objects or blade contact stabilizer/conditioner to the flat surface here machine by hand operating the product and. And deterioration, which could expose moving parts or allow objects ET the Cap getting replacement. & Stratton at 1-800-328-4457. objects 1 to 3 minutes to remove excess replace Dispose of fuel properly ; s for! Engine gasoline to expand check the condition of the fitting ( s ) seem or! The discussion about performance, modifications, classifieds, troubleshooting, maintenance, and more time master crank and! He said customers needing more information should call Briggs & Stratton at 1-800-328-4457. objects Full mark Figure... I wonder if there would be a possibility of getting a replacement tank run it until it will He. Turns or rapid speed changes and remove the blade end using a spring-removal,. Important: Always push the machine is used for jacking points angle as. 32 ) inch ), replace the blade to the if necessary 2002. Gasoline, it is flexible blade with a new blade ; refer to Side-to-Side Leveling the shipping cost back direction...

Shadowplay Doesn T Work, Don't Ya Feel Like Crying, Articles T